Regency P40-LP User Manual

Tested by:FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4918-566bMODELS: P40-NG Natural Gas P40-LP Propane

Regency® P40 Direct Vent Gas Fireplace10INSTALLATIONMANTEL CLEARANCESBecause of the extreme heat this fi replace emits, the mantel clearances are crit

Regency® P40 Direct Vent Gas Fireplace 11INSTALLATIONINSTALLATIONDiagram 11) Frame in the enclosure for the unit with framing material. The framed op

Regency® P40 Direct Vent Gas Fireplace12INSTALLATIONVENTING INTRODUCTIONThe P40 uses the "balanced fl ue" technology Co Axial system. T

Regency® P40 Direct Vent Gas Fireplace 13INSTALLATIONINSTALLATIONEXTERIOR VENT TERMINATION REQUIREMENTSA= Clearance above grade, veranda, porch, deck

Regency® P40 Direct Vent Gas Fireplace14INSTALLATIONVENTING ARRANGEMENTS HORIZONTAL TERMINATION (FLEX)Regency® Direct Vent System These venting syste

Regency® P40 Direct Vent Gas Fireplace 15INSTALLATIONINSTALLATIONRIGID PIPE VENTING SYSTEMSBASIC HORIZONTAL & VERTICAL TERMINATIONSRigid Pipe Vent

Regency® P40 Direct Vent Gas Fireplace16INSTALLATIONRIGID PIPE VENTING COMPONENTS LISTSimpson Dura-Vent components are available directly from FPI.Des

Regency® P40 Direct Vent Gas Fireplace 17INSTALLATIONThe diagram shows all allowable combinations of vertical runs with horizontal terminations, one 9

Regency® P40 Direct Vent Gas Fireplace18INSTALLATIONHH1VHorizontal Venting with Two (2) 90o ElbowsHorizontal Venting with Three (3) 90o ElbowsOne 90o

Regency® P40 Direct Vent Gas Fireplace 19INSTALLATIONVH1HV1V1VHVertical Venting with Two (2) 90o ElbowsVertical Venting with Three (3) 90o ElbowsOne 9

Regency® P40 Direct Vent Gas Fireplace2To the New Owner:Congratulations! You are the owner of a state-of-the-art Gas Fireplace by REGENCY®. The P40 ha

Regency® P40 Direct Vent Gas Fireplace20INSTALLATION• Vent must be supported at offsets.• Firestops are required at each fl oor level and whenever

Regency® P40 Direct Vent Gas Fireplace 21INSTALLATIONDiagram 7Diagram 610) Install wall thimble in the center of the 11" (279mm) square and atta

Regency® P40 Direct Vent Gas Fireplace22INSTALLATION6) Continue to assemble pipe lengths.Note: If an offset is necessary in the attic to avoid obstr

Regency® P40 Direct Vent Gas Fireplace 23INSTALLATION4) Separate the 2 halves of the wall thimble and securely fasten the one with the tabs to the ou

Regency® P40 Direct Vent Gas Fireplace24INSTALLATIONP40-NG SYSTEM DATA For 0 to 4500 feet altitudeFront Burner Orifi ce: #44Back Burner Orifi ce: #35

Regency® P40 Direct Vent Gas Fireplace 25INSTALLATIONGAS PIPE PRESSURE TESTINGThe appliance must be isolated from the gas supply piping system by clos

Regency® P40 Direct Vent Gas Fireplace26INSTALLATIONCONVERSION KIT #502-969 FROM NG TO LPTHIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN

Regency® P40 Direct Vent Gas Fireplace 27INSTALLATIONINSTALLATIONControl Module17) Remove the Control Module, located behind the power module, by lif

Regency® P40 Direct Vent Gas Fireplace28INSTALLATIONIMPORTANTDangerous operating conditions may occur if the panels are broken.1) Unwrap the Brick Pa

Regency® P40 Direct Vent Gas Fireplace 29INSTALLATIONLOG SET INSTALLATIONINSTALLATIONRead the instructions below carefully and refer to the pictures.

Regency® P40 Direct Vent Gas Fireplace 3TABLE OF CONTENTSSIT Valve Description ...25Back-Up Battery Ins

Regency® P40 Direct Vent Gas Fireplace30INSTALLATIONINSTALLATION8) Place log 03-33 on the back burner in between the burner tubes. Slide the log to t

Regency® P40 Direct Vent Gas Fireplace 31INSTALLATION11) Fit log 03-37 on the 4th fender post and rest on the notch in log 03-33.12) Place log 03-38 L

Regency® P40 Direct Vent Gas Fireplace32INSTALLATIONDiagram 1Diagram 3STANDARD FLUSH DOORNOTE: Install Finishing Trim prior to installing the Flush D

Regency® P40 Direct Vent Gas Fireplace 33INSTALLATIONWIRING DIAGRAM CAUTION: Label all wires prior to disconnection when servicing controls. Wiring er

Regency® P40 Direct Vent Gas Fireplace34OPERATIONOPERATING INSTRUCTIONSOPERATING INSTRUCTIONS1) Read and understand these instructions before operati

Regency® P40 Direct Vent Gas Fireplace 35OPERATIONOPERATING INSTRUCTIONSSUMMARY OF CONTROLS For the Manual Control Box, located on right hand side of

Regency® P40 Direct Vent Gas Fireplace36OPERATIONCOPY OF LIGHTING PLATE INSTRUCTIONSNORMAL OPERATING SOUNDS OF GAS APPLIANCESIt is possible that you w

Regency® P40 Direct Vent Gas Fireplace 37MAINTENANCEMAINTENANCE INSTRUCTIONS1) Always turn off the gas valve before cleaning. For relighting, refer t

Regency® P40 Direct Vent Gas Fireplace38MAINTENANCEMAINTENANCECAUTION: Wear gloves when removing damaged or broken glass.WARNING: Do not operate the a

Regency® P40 Direct Vent Gas Fireplace 39MAINTENANCEVALVE REPLACEMENT1) Shut off the main gas supply and unplug the power to the ECS system.2) Remov

Regency® P40 Direct Vent Gas Fireplace4INSTALLATIONThis is a copy of the label that accompanies each P40-NG and P40-LP Direct Vent Gas Fireplace. We

Regency® P40 Direct Vent Gas Fireplace40MAINTENANCEMAINTENANCE15) Disconnect the compression fi tting at the solenoid valve.16) Remove the solenoid val

Regency® P40 Direct Vent Gas Fireplace 41MAINTENANCE1) Unplug the power source.2) Remove the Power Module by lifting it up off of the velcro and pul

Regency® P40 Direct Vent Gas Fireplace42PARTS LISTMAIN ASSEMBLY Part # Description 10)

Regency® P40 Direct Vent Gas Fireplace 43PARTS LISTVALVE TRAY ASSEMBLY Part # Description

Regency® P40 Direct Vent Gas Fireplace44PARTS LISTFLUSH DOOR & LOUVERS Part # Description 502-910

Regency® P40 Direct Vent Gas Fireplace 45NOTES________________________________________________________________________________________________________

Regency® P40 Direct Vent Gas Fireplace46NOTES_________________________________________________________________________________________________________

Regency® P40 Direct Vent Gas Fireplace 47WARRANTYRegency® Fireplace Products are designed with reliability and simplicity in mind. In addition, our in

Regency® P40 Direct Vent Gas Fireplace48Installer: Please complete the following informationDealer Name & Address: _______________________________

Regency® P40 Direct Vent Gas Fireplace 5INSTALLATIONREQUIREMENTS 5.08: Modifications to NFPA-54, Chapter 10(2) Revise 10.8.3 by adding the following a

Regency® P40 Direct Vent Gas Fireplace6INSTALLATIONUNIT DIMENSIONSDimensions

Regency® P40 Direct Vent Gas Fireplace 7INSTALLATION12) Installation and any repairs to this appliance should be done by an authorized service person.

Regency® P40 Direct Vent Gas Fireplace8INSTALLATIONINSTALLATIONThis includes:1) Clocking the appliance to ensure the correct fi ring rate (rate noted

Regency® P40 Direct Vent Gas Fireplace 9INSTALLATIONCLEARANCESThe clearances listed below are minimum distances unless otherwise stated:A major cause