Regency NATURAL GAS U32-NG4 User Manual

FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4918-527MODELS: U32-NG4 Natural Gas U32-LP4 Propa

10 U32-4 FPI Direct Vent Gas Insert6) Place the Left Top Log D)02-46 on the pin on Log C)02-56 and on top of the cutout on Log A)02-43.7) Place the

11U32-4 FPI Direct Vent Gas InsertDiagram 3Rear View: Trim AssemblyDiagram 2Rear View: Faceplate AssemblyDiagram 1REGENCY FACEPLATE & TRIM INSTALL

12 U32-4 FPI Direct Vent Gas InsertTo remove the fl ush door, reverse the above steps.NOTE: The chain must rest on TOP of the gas inlet pipe never unde

13U32-4 FPI Direct Vent Gas InsertBAY LOUVERS1) Install top louver by sliding the two bracket clips into the brackets located on top of the bay door.

14 U32-4 FPI Direct Vent Gas InsertINSTALLATION THIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTERIF IN DOUBT DO NOT DO THIS CONVERSION !!1) Shut

15U32-4 FPI Direct Vent Gas InsertInstallation of the DC Sparker:16) Verify that if the conversion is from NG to LPG, the screw must be re-assembled

16 U32-4 FPI Direct Vent Gas Insert28) Run the other end of the ground wire and DC spark generator wires through the bushing on the heat shield. 30)

17U32-4 FPI Direct Vent Gas InsertFULL SCREEN DOORSINSTALLATION 1) Hold the full screen door frame up against the unit in order to make the following

18 U32-4 FPI Direct Vent Gas InsertINSTALLATION 5) Place Bottom Frame near hinge. Flip hinge over Bottom Frame and secure with 3 screws.4) Install S

19U32-4 FPI Direct Vent Gas InsertHAMPTON® CAST FACEPLATE INSTALLATION1) Lay the faceplate panels fl at, face down on something soft so they don'

2 U32-4 FPI Direct Vent Gas InsertFPI GAS INSERTNote: Oversize faceplate is 44" x 28"TO THE NEW OWNERCongratulations! You are the owner of

20 U32-4 FPI Direct Vent Gas InsertHAMPTON® CAST GRILL INSTALLATIONINSTALLATION Note: The top grill should be placed with the curved cut-out facing up

21U32-4 FPI Direct Vent Gas InsertIMPORTANT: Please use the gloves provided when handling the Kensington® Front to avoid fi ngerprints.3) Slide the Ta

22 U32-4 FPI Direct Vent Gas InsertTHE KENSINGTON® 2-PANEL DOOR INSTALLATION3) Hook the Left Side Screen Door to the Door Frame by placing the door h

23U32-4 FPI Direct Vent Gas InsertOPTIONAL REMOTE CONTROL Use the FPI Remote Control Kit approved for this unit. Use of other systems may void your w

24 U32-4 FPI Direct Vent Gas InsertPiezoIgnitorBlackRedToThermocouple INPilotAssemblyThermostat(Optional)(Millivolt)RemoteReceiver(Optional)(Millivolt

25U32-4 FPI Direct Vent Gas InsertFor PROPANE Units and Units Equipped with DC Spark Boxes**For installation of the DC Spark Box refer to the LP Conve

26 U32-4 FPI Direct Vent Gas InsertThe glass panel may require cleaning after the unit has cooled down. DO NOT ATTEMPT TO CLEAN THE GLASS WHILE IT IS

27U32-4 FPI Direct Vent Gas InsertCOPY OF LIGHTING INSTRUCTION PLATEOPERATING INSTRUCTIONSsounds. You should also be aware that as there are temperatu

28 U32-4 FPI Direct Vent Gas InsertMAINTENANCEGENERAL VENT MAINTENANCEConduct an inspection of the venting system semi-annually. Recommended areas to

29U32-4 FPI Direct Vent Gas InsertFAN MAINTENANCEIf your fan requires maintenance or replacement, access to the fan is through the plate on the rear w

3U32-4 FPI Direct Vent Gas InsertTABLE OF CONTENTSFPI GAS INSERTOPERATING INSTRUCTIONSOperating Instructions ...

30 U32-4 FPI Direct Vent Gas InsertMAINTENANCEVALVE REPLACEMENT1) Shut off the gas supply.2) Remove the louvers (and bay door if it is on).3) Open

31U32-4 FPI Direct Vent Gas InsertPARTS LIST1) 420-122 Fan Access Panel2) 420-142 Gasket - Fan Access Panel 422-518/P Fan Assembly:3) 910-215/P Fa

32 U32-4 FPI Direct Vent Gas Insert697374715258707290915568676866OTLIPOTHTPTPTHTPTHEAAIRINAIRIN53PARTS LIST 423-574/P Valve Assembly - NG 423-576

33U32-4 FPI Direct Vent Gas InsertPARTS LIST Bay Door 420-931 Complete Bay Door with Black Trim102) * Glass Retainer Side (Top & Btm)1

34 U32-4 FPI Direct Vent Gas InsertLOGOPLATEHERELOGOPLATEHERELOGOPLATEHERELOGOPLATEHERE9295STANDARD SIZEDETAIL 'A'9193REAR VIEWFRONT VIEW966

35U32-4 FPI Direct Vent Gas Insert202205187189188203195194194207201 402-971** Cast Faceplates (Set)187) 910-246 Burner On/Off Switch188) 910-330 Fa

36 U32-4 FPI Direct Vent Gas InsertNOTES______________________________________________________________________________________________________________

37U32-4 FPI Direct Vent Gas InsertNOTES_______________________________________________________________________________________________________________

38 U32-4 FPI Direct Vent Gas InsertNOTES______________________________________________________________________________________________________________

39U32-4 FPI Direct Vent Gas InsertWARRANTYFPI Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Quali

4 U32-4 FPI Direct Vent Gas InsertSAFETY LABELThis is a copy of the labels that accompany each U32-4 Gas Insert. We have printed a copy of the content

Installer: Please complete the following informationDealer Name & Address: _______________________________________________________________________

5U32-4 FPI Direct Vent Gas InsertREQUIREMENTS 5.08: Modifications to NFPA-54, Chapter 10(2) Revise 10.8.3 by adding the following additional requireme

6 U32-4 FPI Direct Vent Gas InsertIMPORTANT MESSAGE SAVE THESE INSTRUCTIONSThe FPI Gas Insert must be installed in accordance with these instruction

7U32-4 FPI Direct Vent Gas InsertABDECMANUFACTURED MOBILE HOME ADDITIONAL REQUIREMENTS1) Ensure that structural members are not cut or weakened durin

8 U32-4 FPI Direct Vent Gas InsertVENTINGTHE APPLIANCE MUST NOT BE CONNECTED TO ACHIMNEY FLUE SERVING A SEPARATE SOLID FUELBURNING APPLIANCE.This appl

9U32-4 FPI Direct Vent Gas InsertOPTIONAL BRICK PANEL1) Unwrap the brick pattern panels from the protective wrapping.2) Remove the glass front if it