Regency Energy U32E Medium Gas Insert User Manual

FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4918-846cMODELS: U32E-NG5 Natural Gas U32E-LP5 Pr

10U32E-5 FPI Direct Vent Gas InsertINSTALLATIONVENTINGTHE APPLIANCE MUST NOT BE CONNECTED TO ACHIMNEY FLUE SERVING A SEPARATE SOLID FUELBURNING APPLIA

U32E-5 FPI Direct Vent Gas Insert11INSTALLATIONOPTIONAL BRICK PANEL1) Unwrap the brick pattern panels from the protective wrapping.2) Remove the gla

12U32E-5 FPI Direct Vent Gas InsertINSTALLATIONLOG SET INSTALLATIONLog kit (Part # 425-930) contains the following pieces: a) 27-31 Rear Log b) 27-3

U32E-5 FPI Direct Vent Gas Insert13INSTALLATION6) Fit the groove in log 27-34 into the tab on the right side of the burner. Rest the other end of log

14U32E-5 FPI Direct Vent Gas InsertINSTALLATION8) Fit log 27-36 into the pins on logs 27-33 and 27-31.9) Place embers along the front of the burner

U32E-5 FPI Direct Vent Gas Insert15INSTALLATIONCompleted Log Set Installation27-3327-3227-3127-3627-3427-35

16U32E-5 FPI Direct Vent Gas InsertINSTALLATIONDiagram 3Rear View: Trim AssemblyDiagram 2Rear View: Faceplate AssemblyDiagram 11) Lay the faceplate p

U32E-5 FPI Direct Vent Gas Insert17INSTALLATIONTo remove the fl ush door, reverse the above steps.NOTE: The chain must rest on TOP of the gas inlet pip

18U32E-5 FPI Direct Vent Gas InsertINSTALLATIONEach Kit contains one LPG Conversion Kit #514-972LPG Conversion Kit Contains:Qty. Part # Description1

U32E-5 FPI Direct Vent Gas Insert19INSTALLATIONFULL SCREEN DOORS1) Hold the full screen door frame up against the unit in order to make the following

2U32E-5 FPI Direct Vent Gas InsertTO THE NEW OWNERCongratulations! You are the owner of a state-of-the-art Gas Insert by FPI.The FPI Gas Insert Serie

20U32E-5 FPI Direct Vent Gas InsertINSTALLATION5) Place Bottom Frame near hinge. Flip hinge over Bottom Frame and secure with 3 screws.4) Install Sp

U32E-5 FPI Direct Vent Gas Insert21INSTALLATION3) Position faceplate on unit lining up screw holes on faceplate with screw holes on unit - se

22U32E-5 FPI Direct Vent Gas InsertINSTALLATION7) Install the door frame by hooking the top fl ange over the top of the glass door.9) Run supplied 12

U32E-5 FPI Direct Vent Gas Insert23INSTALLATIONThe Hearth Trim is an option that can be used to fi nish off the installation when the bottom of the fi r

24U32E-5 FPI Direct Vent Gas InsertINSTALLATION3) Connect the female ends of the ON/OFF switch - to the ON/OFF switch in the control box.1) Attach

U32E-5 FPI Direct Vent Gas Insert25INSTALLATION9) Install the top door pressure retainer, required.10) Take the outer faceplate, line up the opening

26U32E-5 FPI Direct Vent Gas InsertINSTALLATIONHearth Trim is an option that can be used to fi nish off the installation when the bottom of the fi repla

U32E-5 FPI Direct Vent Gas Insert27INSTALLATIONOPTIONAL REMOTE CONTROL Use the FPI Remote Control Kit approved for this unit. Use of other systems ma

28U32E-5 FPI Direct Vent Gas InsertINSTALLATION6) Identify wires in the GT remote wiring harness. (See attached wiring diagram for details. )7)

U32E-5 FPI Direct Vent Gas Insert29INSTALLATIONGTM REMOTE INSTALLATION4) Remove DFC (digital fi rebox control box) from the fl oor of the unit.5) Disc

U32E-5 FPI Direct Vent Gas Insert3DIMENSIONSNote: Oversize faceplate is 44" x 28"13-3/4"20"21-1/16"1-3/8"10-3/4"28&

30U32E-5 FPI Direct Vent Gas InsertINSTALLATION12) Plug receiver wire harness wires from the receiver into the DFC box.13) Reinstall the DFC box on

U32E-5 FPI Direct Vent Gas Insert31INSTALLATIONWIRING DIAGRAMSThis heater does not require a 120V A.C. supply for operation. In case of a power failur

32U32E-5 FPI Direct Vent Gas Insert3232U32E-5 FPI Direct Vent Gas Insert32OPERATING INSTRUCTIONSOPERATING INSTRUCTIONSCOPY OF LIGHTING INSTRUCTION PLA

U32E-5 FPI Direct Vent Gas Insert3333INSTALLATIONOPERATING INSTRUCTIONSAUTOMATIC CONVECTION FAN OPERATIONThe fan operates automatically, turn the kno

34U32E-5 FPI Direct Vent Gas Insert34OPERATING INSTRUCTIONSMAINTENANCE INSTRUCTIONS1) Always turn the gas valve to off before cleaning. For relighti

U32E-5 FPI Direct Vent Gas Insert35MAINTENANCEGENERAL VENT MAINTENANCEConduct an inspection of the venting system semi-annually. Recommended areas to

36U32E-5 FPI Direct Vent Gas Insert36U32E-5 FPI Direct Vent Gas InsertMAINTENANCEMAINTENANCEFAN MAINTENANCEIf your fan requires maintenance or replace

U32E-5 FPI Direct Vent Gas Insert37MAINTENANCEVALVE REPLACEMENT1) Shut off the gas supply.2) Remove the louvers (and bay door if installed).3) Open

38U32E-5 FPI Direct Vent Gas InsertPARTS LISTPARTS LIST2121BRICK PANEL SET36343312444242464547485043513635312517718131915141681052539411) 420-122 Fan

U32E-5 FPI Direct Vent Gas Insert39PARTS LIST73747152587072905566 423-574E/P Valve Assembly - NG 423-576E/P Valve Assembly - LP52) 911-004 Valve

4U32E-5 FPI Direct Vent Gas InsertTABLE OF CONTENTSREQUIREMENTSMA Code - CO Detector...6(for the State o

40U32E-5 FPI Direct Vent Gas InsertPARTS LISTFLUSH FRONT149137112112112140112137137135139137FLUSH FRONT ASSEMBLY Part # Description

U32E-5 FPI Direct Vent Gas Insert41PARTS LISTLOGOPLATEHERELOGOPLATEHERELOGOPLATEHERELOGOPLATEHERE9295STANDARD SIZEDETAIL 'A'9193REAR VIEWFRO

42U32E-5 FPI Direct Vent Gas InsertPARTS LISTCONTEMPORARY FACEPLATE AND DOOR FRAME Part # Description3121) 425-512 Door Bottom Assembly2

U32E-5 FPI Direct Vent Gas Insert43PARTS LISTLOW PROFILE FACEPLATE Part # Description1) * Backplate Assembly2) *

44U32E-5 FPI Direct Vent Gas InsertNOTES

U32E-5 FPI Direct Vent Gas Insert45NOTES

46U32E-5 FPI Direct Vent Gas InsertNOTES

U32E-5 FPI Direct Vent Gas Insert47WARRANTYRegency Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal

Printed in CanadaFPI, Regency® ,Hampton® and SureFire are trademarks of FPI Fireplace Products International Ltd.© Copyright 2012, FPI Fireplace Produ

U32E-5 FPI Direct Vent Gas Insert5SAFETY LABELThis is a copy of the labels that accompany each U32E-5 Gas Insert. We have printed a copy of the conten

6U32E-5 FPI Direct Vent Gas Insert6U32E-5 FPI Direct Vent Gas InsertREQUIREMENTSREQUIREMENTS5.08: Modifications to NFPA-54, Chapter 10(2) Revise 10.8.

U32E-5 FPI Direct Vent Gas Insert7U32E-5 FPI Direct Vent Gas Insert7INSTALLATIONINSTALLATIONIMPORTANT MESSAGE SAVE THESE INSTRUCTIONSThe U32E-5 Gas

8U32E-5 FPI Direct Vent Gas InsertINSTALLATIONIMPORTANT MESSAGE SAVE THESE INSTRUCTIONSThe FPI Gas Insert must be installed in accordance with these

U32E-5 FPI Direct Vent Gas Insert9INSTALLATIONABDECMANUFACTURED MOBILE HOME ADDITIONAL REQUIREMENTS1) Ensure that structural members are not cut or w