Regency Excalibur EX-U31 Medium Gas Insert User Manual

WARNING: If the information in these instructions are not followed ex-actly, a fi re or explosion may result causing property damage, personal injury

10Regency U31-3 Gas Fireplace InsertINSTALLATIONTHIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !!Conver

Regency U31-3 Gas Fireplace Insert11INSTALLATIONGAS CONNECTION 3) Locate the center point where the vent will pass through the chimney above the appl

12Regency U31-3 Gas Fireplace InsertINSTALLATIONDiagram 13) After fi ve minutes, test that there is a “pull” on the fl ue by placing a smoke match, cig

Regency U31-3 Gas Fireplace Insert13INSTALLATIONLOG SET INSTALLATIONRead the instructions below carefully and refer to the diagrams. If logs are brok

14Regency U31-3 Gas Fireplace InsertINSTALLATIONLogs D)02-46 and E)02-47 in position.6) Place the Left Top Log D)02-46 on the pin on Log C)02-56 an

Regency U31-3 Gas Fireplace Insert15INSTALLATION10) Place the embers and Rockwool on the exposed front burner tray.9) Place Front Left Log G)02-44 o

16Regency U31-3 Gas Fireplace InsertINSTALLATIONDiagram 4Diagram 5Rear View: Trim AssemblyDiagram 2Diagram 3Rear View: Faceplate AssemblyDiagram 1FACE

Regency U31-3 Gas Fireplace Insert17INSTALLATIONFLUSH FRONT INSTALLATION1) Install Logs before going on to the next step. See the Log Installation

18Regency U31-3 Gas Fireplace InsertINSTALLATIONWIRING DIAGRAMThis heater does not require a 120V A.C. supply for operation. In case of a power failur

Regency U31-3 Gas Fireplace Insert19INSTALLATIONFULL SCREEN FRONT1) Hold the full screen door up against the unit in order to make the following wire

2Regency U31-3 Gas Fireplace InsertFPI GAS FIREPLACE INSERTTO THE NEW OWNERCongratulations! You are the owner of a state-of-the-art Gas Insert by FP

20Regency U31-3 Gas Fireplace InsertINSTALLATION1) Align the left side Faceplate Trim Bracket with the Firebox Flange and secure using 2 screws as sh

Regency U31-3 Gas Fireplace Insert21INSTALLATION5) Place the bottom hooks of the Surround into the bottom slots of the Faceplate. Slightly pull up th

22Regency U31-3 Gas Fireplace InsertINSTALLATION1) Attach the inner faceplate panel to the insert body using 4 screws in the locations shown below.Di

Regency U31-3 Gas Fireplace Insert23INSTALLATIONDiagram 12Diagram 11Outer faceInner faceplatepanel pinsDiagram 1311) Take the outer faceplate, line u

24Regency U31-3 Gas Fireplace Insert24OPERATING INSTRUCTIONSOPERATING INSTRUCTIONS Before operating this appliance, proceed through the following chec

Regency U31-3 Gas Fireplace Insert2525INSTALLATIONOPERATING INSTRUCTIONSCOPY OF LIGHTING INSTRUCTION PLATESHUTDOWN PROCEDURE1) Use the rocker switch

26Regency U31-3 Gas Fireplace InsertMAINTENANCETop View of pilot fl ameCorrect fl ame pattern has four strong blue fl ames: 1 fl owing around the thermop

Regency U31-3 Gas Fireplace Insert27MAINTENANCEFAN MAINTENANCECAUTION: Label all wires prior to disconnection when servicing con-trols. Wiring error c

28Regency U31-3 Gas Fireplace InsertPARTS LIST1) 400-011 Fan Opening Cover2) 911-071/P Fan Motor (120 V)5) 910-750 Power Cord (120 V) 910-752

Regency U31-3 Gas Fireplace Insert29PARTS LIST67 404-574/P Valve Assembly - NG 404-576/P Valve Assembly - LP52) 910-568 SIT 820 Valve -NG/LP**53

Regency U31-3 Gas Fireplace Insert3DIMENSIONSNote: Oversize faceplate is 44" x 28" (1118 mm x 711mm)Low Profi le Faceplate Dimensions40-3/4 (

30Regency U31-3 Gas Fireplace InsertPARTS LISTFlush Front Assembly Part # Description Flush Door 402-515/P Complete

Regency U31-3 Gas Fireplace Insert31PARTS LIST 402-919 Complete Faceplate (Set) with Black Trim - Oversize41) * Faceplate Side Right - Oversize42)

32Regency U31-3 Gas Fireplace InsertPARTS LIST

Regency U31-3 Gas Fireplace Insert33PARTS LIST12435LOW PROFILE FACEPLATE Part # 403-954 Description1) * Back plate Assembly2) *

34Regency U31-3 Gas Fireplace InsertNOTES

Regency U31-3 Gas Fireplace Insert35WARRANTYRegency® Fireplace Products are designed with reliability and simplicity in mind. In addition, our interna

Printed in CanadaFPI and Regency® are trademarks of FPI Fireplace Products International Ltd.© Copyright 2012, FPI Fireplace Products International Lt

4Regency U31-3 Gas Fireplace InsertTABLE OF CONTENTSOPERATING INSTRUCTIONSOperating Instructions ...24Lighti

Regency U31-3 Gas Fireplace Insert5This is a copy of the labels that accompany each U31-3Gas Insert. We have printed a copy of the contents here for y

6Regency U31-3 Gas Fireplace InsertREQUIREMENTS5.08: Modifications to NFPA-54, Chapter 10(2) Revise 10.8.3 by adding the following additional requirem

Regency U31-3 Gas Fireplace Insert7INSTALLATIONCLOTHING OR OTHER FLAMMABLE MATERIAL SHOULD NOT BE PLACED ON OR NEAR THE APPLIANCE. CHILDREN AND ADUL

8Regency U31-3 Gas Fireplace InsertINSTALLATIONIMPORTANT: SAVE THESE INSTRUCTIONSThe Regency Gas Insert must be installed in accordance with these i

Regency U31-3 Gas Fireplace Insert9INSTALLATIONNOTE: Mantel clearances for Installation into a Zero Clearance Kit are different. Please refer to the Z