Regency Horizon HZ33CE Small Gas Fireplace User Manual

WARNING: If the information in these instructions are not followed exactly, a fi re or explosion may result causing property damage, personal injury o

10Regency HZ33CE Gas FireplaceINSTALLATIONCaution RequirementsThe top, back and sides of the fi replace are defi ned by standoffs. The metal ends of the

Regency HZ33CE Gas Fireplace11INSTALLATIONMANTEL CLEARANCESNote: Ensure the paint that is used on the mantel and the facing is "heat resistant&q

12Regency HZ33CE Gas FireplaceINSTALLATIONFRAMING & FINISHING1. Frame in the enclosure for the unit with framing material. Note: When construct

Regency HZ33CE Gas Fireplace13INSTALLATION29-7/16"747mm21-3/8"[542mm]NO FACING ORFINISHING MATERIALIN THIS AREANo CombustibleMaterials in th

14Regency HZ33CE Gas FireplaceINSTALLATIONMLKPQONOpening for gasconnectionJIFloorDETAIL NSCALE 1 : 62X4 HEADERNNon-combustibleHeader(steel studon edge

Regency HZ33CE Gas Fireplace15INSTALLATIONVENTING INTRODUCTIONThe HZ33CE uses the "balanced fl ue" technology Co-Axial system. The inner

16Regency HZ33CE Gas FireplaceINSTALLATIONEXTERIOR VENT TERMINATION REQUIREMENTSMinimum Clearance RequirementsCanada1USA2A Clearance above grade, vera

Regency HZ33CE Gas Fireplace17INSTALLATIONWherever necessary due to external location of cap, the AstroCap can be replaced with the FPI Riser Vent Ter

18Regency HZ33CE Gas FireplaceINSTALLATIONPipe LengthVerticalTerminalStorm CollarFlashingCeiling FirestopAdj.Pipe Length11" - 14-5/8”90 ElbowoHor

Regency HZ33CE Gas Fireplace19INSTALLATIONDescriptionSimpsonDirect Vent Pro®SelkirkDirect Temp™American MetalProducts®Amerivent DirectMetal-Fab™Sure S

2Regency HZ33CE Gas FireplaceTo the New Owner:Congratulations! You are the owner of a state-of-the-art Gas Fireplace by REGENCY®. The HZ33CE has been

20Regency HZ33CE Gas FireplaceINSTALLATIONDescriptionSimpsonDirect Vent Pro®SelkirkDirect Temp™American MetalProducts®Amerivent DirectMetal-Fab™Sure S

Regency HZ33CE Gas Fireplace21INSTALLATIONRIGID PIPE VENTING ARRANGEMENTS Vertical Terminations(Propane & Natural Gas)The shaded area in the diagr

22Regency HZ33CE Gas FireplaceINSTALLATIONFlex LinerExhaustFlueA maximumof two certifiedjoiner kitsmay be usedper length.#948-30535 ft (11m)Air Intake

Regency HZ33CE Gas Fireplace23INSTALLATIONVENTING ARRANGEMENTS - VERTICAL TERMINATIONS with Co-linear Flex System for bothResidential & Manufactur

24Regency HZ33CE Gas FireplaceINSTALLATION162468101214200122061430” (762mm) / 26” (660mm) when using flexMinimumHeightRequirement4810181816Vertical He

Regency HZ33CE Gas Fireplace25INSTALLATIONHorizontal Venting with Two (2. 90o ElbowsHorizontal Venting with Three (3. 90o ElbowsOne 90o elbow = Two 45

26Regency HZ33CE Gas FireplaceINSTALLATIONHorizontal Venting with Three (3. 90o ElbowsVertical Venting with Two (2. 90o ElbowsVertical Venting with Tw

Regency HZ33CE Gas Fireplace27INSTALLATIONVertical Venting with Three (3. 90o ElbowsVertical Venting with Three (3. 90o Elbows Option

28Regency HZ33CE Gas FireplaceINSTALLATIONRiser VentTerminationMin. 6-1/4"*(159mm)Diagram 3UNIT INSTALLATION WITH HORIZONTAL TERMINATIONDiagram 1

Regency HZ33CE Gas Fireplace29INSTALLATIONGAS LINE INSTALLATIONThe gas line is brought through the right side of the appliance. The gas valve is situa

Regency HZ33CE Gas Fireplace3MANUFACTURED MOBILE HOME REQUIREMENTSINFORMATION FOR MOBILE/MANUFACTURED HOMES AFTER FIRST SALEThis Regency® product has

30Regency HZ33CE Gas FireplaceINSTALLATIONGAS PIPE PRESSURE TESTINGThe appliance must be isolated from the gas supply piping system by closing its ind

Regency HZ33CE Gas Fireplace31INSTALLATIONCONVERSION KIT# 434-972 FROM NG TO LPFor HZ33CE using SIT 886 NOVA Gas ValveTHIS CONVERSION MUST BE DONE BY

32Regency HZ33CE Gas FireplaceINSTALLATION6) Identify wires in the GT remote wiring harness. (see wiring diagram.)7) Connect the TPTH and TH wir

Regency HZ33CE Gas Fireplace33INSTALLATIONGTM REMOTE INSTALLATION6) Identify wires in the GTM/GTMF remote wiring harness. (see wiring diagram.)7

34Regency HZ33CE Gas FireplaceINSTALLATION10) Install the stepper motor in the same location the hi/lo knob was removed from - with 2 screws as

Regency HZ33CE Gas Fireplace35INSTALLATIONWIRING DIAGRAMS This heater does not require a 120V A.C. supply for operation. In case of a power failure, t

36Regency HZ33CE Gas FireplaceINSTALLATIONIMPORTANT: If the optional remote control is used, the AA batteries normally installed into the battery hol

Regency HZ33CE Gas Fireplace37INSTALLATIONAn optional AC power adaptor may be installed as a constant power source for the SureFire system. NOTE: AC

38Regency HZ33CE Gas FireplaceINSTALLATIONINSTALLING THE OPTIONAL FAN (PRIOR TO UNIT INSTALLATION)4. Connect fan ground cable to ground lug. Refer to

Regency HZ33CE Gas Fireplace39INSTALLATIONNOTE: Wiring schematics for P36E-4 (120 Volts),plug-in fan circuit with speed control switch on wall.Lockwas

4Regency HZ33CE Gas FireplaceTABLE OF CONTENTSSAFETY LABELCopy of Safety Decal ...5REQUIREMENTSMA Co

40Regency HZ33CE Gas FireplaceINSTALLATION9. Secure fan by pushing fan down onto mounting pins located on fl oor of unit. Take care not to damage the

Regency HZ33CE Gas Fireplace41INSTALLATIONWALL SWITCH1. Run the supplied wire through the right or left side gas inlet opening. Be careful not to da

42Regency HZ33CE Gas FireplaceINSTALLATIONOPTIONAL REFLECTIVE PANEL INSTALLATION1. Remove fl ush glass door and fi rebox base tray by removing 6 screws

Regency HZ33CE Gas Fireplace43INSTALLATIONGLASS CRYSTALS AND OPTIONAL STONESINSTALLATION ON BURNER AND FIREBOX FLOORGlass Crystals shown on Burner and

44Regency HZ33CE Gas FireplaceINSTALLATIONRead the instructions below carefully and refer to the images. If the logs are broken do not use the unit un

Regency HZ33CE Gas Fireplace45INSTALLATION9. Place Left Log (2 ) match pin landing on Log 2 with pin on Log 1, the bottom should rest on the glass a

46Regency HZ33CE Gas FireplaceINSTALLATIONHZ30E shown - Final InstallHZ30E shown - Log 3 installHZ30E shown - Log 3 install21434. Position Log 3, l

Regency HZ33CE Gas Fireplace47INSTALLATIONGLASS SCREEN GUARD AND GLASS DOOR INSTALLATION& Screen DoorSTANDARD FLUSH DOOR AND SCREENBoth the standa

48Regency HZ33CE Gas FireplaceINSTALLATIONOPTIONAL 4-SIDED FACEPLATE INSTALLATIONIf installing the optional faceplate ensure the combustible and non c

Regency HZ33CE Gas Fireplace49INSTALLATIONIf installing the optional mantel ensure the combustible and non combustible material around the unit are in

Regency HZ33CE Gas Fireplace5SAFETY LABELThis is a copy of the label that accompanies each HZ33CE Direct Vent Gas Fireplace. We have printed a copy of

50Regency HZ33CE Gas Fireplace50OPERATING INSTRUCTIONSOPERATING INSTRUCTIONS1. Read and understand these instructions before operating this appliance

Regency HZ33CE Gas Fireplace5151INSTALLATIONOPERATING INSTRUCTIONSCOPY OF LIGHTING PLATE INSTRUCTIONS918-628bA) This appliance is equipped with an i

52Regency HZ33CE Gas FireplaceMAINTENANCEMAINTENANCE INSTRUCTIONS1. Always turn off the gas valve before cleaning. For relighting, refer to lighting

Regency HZ33CE Gas Fireplace53MAINTENANCEVALVE TRAY REPLACEMENTRemoving Valve1. Shut off the gas supply.2. Remove the faceplate.3. Open the fl ush d

54Regency HZ33CE Gas FireplacePARTS LISTMAIN ASSEMBLY14146127510813112315Part # Description1 770-523 Thermodisc Cage Assy2 904-434 Orifi ce #47 NG904-2

Regency HZ33CE Gas Fireplace55PARTS LIST2143ACCESSORIESPart # Description1 434-044 Enamel Panel Top2 434-042 Enamel Panel Left3 434-041 Enamel Panel R

56Regency HZ33CE Gas FireplaceNOTES

Regency HZ33CE Gas Fireplace57NOTES

58Regency HZ33CE Gas FireplaceNOTES

Regency HZ33CE Gas Fireplace59WARRANTYRegency® Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Qual

6Regency HZ33CE Gas FireplaceREQUIREMENTS5.08: Modifications to NFPA-54, Chapter 10(2) Revise 10.8.3 by adding the following additional requirements:

Printed in CanadaRegency Horizon and SureFire are trademarks of FPI Fireplace Products International Ltd.© Copyright 2014, FPI Fireplace Products Inte

Regency HZ33CE Gas Fireplace7DIMENSIONSUNIT DIMENSIONS4 SIDED FACEPLATE DIMENSIONSMANTEL DIMENSIONS34-9/16"16"407mm23"584mm[878mm]26-1/

8Regency HZ33CE Gas FireplaceINSTALLATIONEmissions from burning wood or gas could contain chemicals known to the State of California to cause cancer

Regency HZ33CE Gas Fireplace9INSTALLATIONThis includes:1. Clocking the appliance to ensure the correct fi ring rate (rate noted on label), after burni