Regency Horizon HZO42 Outdoor Gas Fireplace User Manual

WARNING: If the information in these instructions are not followed exactly, a fi re or explosion may result causing property damage, personal injury

10Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONFRAMING DIMENSIONSABCDMetal Studon edgeGFNote: All other framing maybe of wood construction.EFraming

Regency Horizon™ HZO42 Gas Fireplace11INSTALLATIONDue to the extreme heat this fi replace emits, the mantel clearances are critical. Combustible mantel

12Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONFINISHINGIMPORTANT FINISHING DETAIL NOTE: Before placing unit into fi nal position - it is

Regency Horizon™ HZO42 Gas Fireplace13INSTALLATIONGAS PIPE PRESSURE TESTINGThe appliance must be isolated from the gas sup-ply piping system by closin

14Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONUNIT ASSEMBLY PRIOR TO INSTALLATIONNAILING STRIPSThe nailing strips come attached to the unit. There

Regency Horizon™ HZO42 Gas Fireplace15INSTALLATIONDRAIN INSTALLATION (RECOMMENDED)Although this fi replace is designed to operate outdoors safely, rain

16Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONWALL SWITCH AND BATTERY INSTALLATION(INCLUDED WITH UNIT)The unit comes with low voltage wire and a b

Regency Horizon™ HZO42 Gas Fireplace17INSTALLATIONWIRING DIAGRAMThis heater does not require a 120V A.C. supply for operation. (Do not cut the ground

18Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONINNER PANEL INSTALLATIONBefore installation, panels must be handled and cleaned as per instructions

Regency Horizon™ HZO42 Gas Fireplace19INSTALLATIONGLASS CRYSTAL INSTALLATION Spread the Glass Crystals or Stones evenly over the burner. Ensure the cr

2Regency Horizon™ HZO42 Gas Fireplace2To the New Owner:Congratulations! You are the owner of a state-of-the-art Gas Fireplace by REGENCY®. The Horizon

20Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONVOLCANIC STONE INSTALLATION OUTDOOR VOLCANIC STONE BURNER PACKAGESUnit Volcanic StonesIvory/TanVolca

Regency Horizon™ HZO42 Gas Fireplace21INSTALLATIONOPTIONAL LOG SET INSTALLATIONInstallation of Refl ective Panels must be completed before installing t

22Regency Horizon™ HZO42 Gas FireplaceINSTALLATION4) Install log D on the burner as shown below. Orient log D across log E in the same way and in

Regency Horizon™ HZO42 Gas Fireplace23INSTALLATIONHEAT DEFLECTOR INSTALLATION1) Install the heat defl ector to the top inside of the fi rebox with 4 sc

24Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONFACEPLATE INSTALLATIONRemove the protective coating from the faceplate before installation - see han

Regency Horizon™ HZO42 Gas Fireplace25INSTALLATIONWEATHER COVER INSTALLATION / REMOVAL1) To install the glass wind shield - slot it into the space bet

26Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONASSEMBLY INSTRUCTIONS FOR A STEEL STUD FRAMING KIT FOR HZO42Follow these instructions to construct a

Regency Horizon™ HZO42 Gas Fireplace27INSTALLATION1) Place top/bottom (A) on the ground - fl at side down. Bend the tabs up to a 90° angle.2) Pos

28Regency Horizon™ HZO42 Gas FireplaceINSTALLATION6) Manoeuvre remaining (B) pieces and position in each corner of the frame - fl at side facing o

Regency Horizon™ HZO42 Gas Fireplace29INSTALLATION12) LIne up screw holes on (E) (header) and (B) (inner vertical support). Secure with 2 wafer

Regency Horizon™ HZO42 Gas Fireplace333TABLE OF CONTENTSSAFETY LABELCopy of Safety Decal ...4DIMENSI

30Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONREMOTE PROPANE / LP GAS ENCLOSURES INSTALLATION GUIDELINES If the unit is permanently connected to a

Regency Horizon™ HZO42 Gas Fireplace3131INSTALLATIONOPERATING INSTRUCTIONSAERATION ADJUSTMENTOpen the air shutter for a blue fl ame or close for a yell

32Regency Horizon™ HZO42 Gas Fireplace32OPERATING INSTRUCTIONSCOPY OF LIGHTING PLATE INSTRUCTIONSFOR YOUR SAFETY READ BEFORE LIGHTINGA) This applian

Regency Horizon™ HZO42 Gas Fireplace33MAINTENANCEMAINTENANCE INSTRUCTIONS1) Always turn off the gas valve and unplug the batteries before cleaning. F

34Regency Horizon™ HZO42 Gas FireplaceMAINTENANCEVALVE ASSEMBLY REPLACEMENT1) Turn the unit off and allow it to cool down to room temperature.2) Tur

Regency Horizon™ HZO42 Gas Fireplace35MAINTENANCE14) Remove 6 screws an lift out valve tray.16) Replace with new valve tray and reverse steps. Inspec

36Regency Horizon™ HZO42 Gas FireplaceMAINTENANCEDIGITAL FIREPLACE BURNER CONTROL REMOVAL5. Disconnect the Black sparker wire with black spade connec

Regency Horizon™ HZO42 Gas Fireplace37PARTS LISTMAIN ASSEMBLY Part # Description 1)

38Regency Horizon™ HZO42 Gas FireplacePARTS LISTBURNER ASSEMBLY9121110 Part # Description 9) 326-525 Burner Assemb

Regency Horizon™ HZO42 Gas Fireplace39PARTS LISTACCESSORIES Part # Description 13) 326-907 Refl ective Stainless St

4Regency Horizon™ HZO42 Gas FireplaceSAFETY LABELThis is a copy of the label that accompanies each HZO42 Outdoor Fireplace. We have printed a copy of

40Regency Horizon™ HZO42 Gas FireplaceNOTES

Regency Horizon™ HZO42 Gas Fireplace41NOTES

42Regency Horizon™ HZO42 Gas FireplaceNOTES

Regency Horizon™ HZO42 Gas Fireplace43WARRANTYRegency® Fireplace Products are designed with reliability and simplicity in mind. In addition, our inter

Regency Horizon is a trademark of FPI Fireplace Products International Ltd. © Copyright 2014, FPI Fireplace Products International Ltd. All rights res

Regency Horizon™ HZO42 Gas Fireplace5DIMENSIONSUNIT DIMENSIONS41 - 11/16” (1059mm)35 - 1/4” (895mm)23 - 5/16” (592mm)6 - 5/16” (160mm)16 - 1/8” (410mm

6Regency Horizon™ HZO42 Gas FireplaceINSTALLATIONIMPORTANT MESSAGE SAVE THESE INSTRUCTIONSThe HZO42 Gas Fireplace must be installed in accordance wi

Regency Horizon™ HZO42 Gas Fireplace7INSTALLATIONLOCATING YOUR GAS FIREPLACE1) When selecting a location for your fi replace, ensure that the clearanc

8Regency Horizon™ HZO42 Gas FireplaceINSTALLATION• Never insulate around the body of the unit• Excessive heat retention in the fi rebox will lead to

Regency Horizon™ HZO42 Gas Fireplace9INSTALLATIONCaution RequirementsThe top, back and sides of the fi replace are defi ned by standoffs. The metal ends