Regency Liberty L390PB Medium Gas Insert User Manual

FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4919-275cMODELS: L390PB-NG2 / HZI390PB- NG2 Natural

10L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONABCEDCF1DGFC222DHCMATERIALS REQUIREDNo electrical power supply is required for the gas contr

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert11INSTALLATIONDiagram 1Diagram3Diagram 2MINIMUM CLEARANCES TO COMBUSTIBLESThe clearances listed below are

12L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONVENTINGTHE APPLIANCE MUST NOT BE CONNECTED TO ACHIMNEY FLUE SERVING A SEPARATE SOLID FUELBUR

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert13INSTALLATION1) Detach the Flue Connector Plate from the unit by removing the Connector Plate Sc

14L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONLEVELLING LEG ADJUSTMENT The L390PB / HZI390PB inserts are equipped with 2 levelling legs

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert15INSTALLATIONAir Shutters are required to increase or decrease the amount of air that is mixed with the f

16L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONGAS PIPE PRESSURE TESTINGThe appliance must be isolated from the gas sup-ply piping system b

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert17INSTALLATIONBefore you begin:Shut off the gas supply to the unit. Disconnect all electrical supply to th

18L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATION13. Verify that if the conversion is from NG to LPG, the screw must be re-assembled with t

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert19INSTALLATIONGT REMOTE INSTALLATIONNote: GT remote control installation must be completed prior to the u

2L390PB-2 / HZI390PB-2 Direct Vent Gas InsertTO THE NEW OWNERCongratulations! You are the owner of a state-of-the-art Gas Insert by Regency.The Regen

20L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONGTM REMOTE INSTALLATIONNote: GTM remote control installation must be completed prior to the

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert21INSTALLATION9. Connect receiver wire from the wiring harness to the back side of the remote receiver as

22L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONGTMF REMOTE INSTALLATIONNote: GTMF remote control installation must be completed prior to t

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert23INSTALLATION9. Bundle excess wires and power cord - with the exception of the wire marked receiver.

24L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONCAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can c

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert25INSTALLATIONWIRING DIAGRAM FOR GTMF REMOTENeutralLiveBlackBlackMinimum ConvectionAir Temp. SwitchGroundO

26L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONOptional WALL SWITCH1) Run the supplied 10' of wire through the right or left side gas

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert27INSTALLATIONGLASS CRYSTAL / STONE INSTALLATIONSpread the Glass Crystals or Stones evenly over the burner

28L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONCAUTIONDO NOT place spa stones over pilot and burner ports.No spa stones in this area.Inst

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert29INSTALLATION HZI390PB OPTIONAL LOG SET INSTALLATION Ensure unit is cooled to room temperature and remov

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert3DIMENSIONS3978"10141478"3772418"61417"4311912"4942534"6542738"6972618&

30L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATION7361324390 Pin Landing540 Pin Landing1456. Place Log 4, match pin locator on Log 4 with lan

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert31INSTALLATION L390PB LOG SET INSTALLATION 1) Identify Log 1 pins on left side of log burner in unit - se

32L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATION919-238 02/15/135) Position Log 3 in front and to the right of Log 1. Log 3 fi ts in a reces

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert33INSTALLATION11) Match up pin on Log 5 with locator on Log 6 as shown below.12) Rest Log 6 in notch on

34L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONExhaust BaeScrews help to locatethe Exhaust Baffle wheninstalling in the FireboxExhaust Baf

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert35INSTALLATIONBRICK PANEL INSTALLATIONBrick Panel Installation Brick panels are soft and fragile. Use caut

36L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONENAMEL PANEL INSTALLATIONSheet metal components may have sharp edges. Please handle with car

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert37INSTALLATIONGLASS DOOR REMOVAL / INSTALLATION2) Pull forward until the lower door latch is disengaged f

38L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATION3 SIDED LOW PROFILE FACEPLATE INSTALLATIONNote: Faceplate may be installed after the unit is

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert39INSTALLATIONOPTIONAL HEARTH TRIMINSTALLATIONHearth Trim is an option that can be used to fi nish off the

4L390PB-2 / HZI390PB-2 Direct Vent Gas Insert4TABLE OF CONTENTSEnamel panel installation...36Glass door remo

40L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONOPTIONAL SCREEN INSTALLATION1) Install the optional screen by hooking the top of the screen

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert4141OPERATING INSTRUCTIONSDO NOT ATTEMPT TO CLEAN THE GLASS WHILE IT IS HOT. Note: When the glass is cold

42L390PB-2 / HZI390PB-2 Direct Vent Gas Insert42OPERATING INSTRUCTIONSCOPY OF LIGHTING INSTRUCTION PLATENORMAL OPERATING SOUNDS OF GAS APPLIANCESIt is

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert43MAINTENANCEWARNING: CHILDREN AND ADULTS SHOULD BE ALERTED TO THE HAZARDS OF HIGH SURFACE TEMPERATURE AN

44L390PB-2 / HZI390PB-2 Direct Vent Gas InsertMAINTENANCEGENERAL VENT MAINTENANCEConduct an inspection of the venting system semi-annually. Recommende

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert45MAINTENANCEGLASS CRYSTAL BURNER REMOVAL / INSTALLATION HZI390PB Care must be taken when installing the b

46L390PB-2 / HZI390PB-2 Direct Vent Gas InsertMAINTENANCEBurner MountingBracket RightBurner MountingBracket LeftMixing TubeSupportGas OrficePilot Asse

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert47MAINTENANCEFAN REMOVAL / INSTALLATION2. Lift fan bracket and fan off pins from base of unit.6. Reverse

48L390PB-2 / HZI390PB-2 Direct Vent Gas InsertMAINTENANCEVALVE REPLACEMENTBefore you begin:* Shut off the gas supply to the unit. Disconnect electr

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert49PARTS LISTMAIN ASSEMBLY Part #

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert5SAFETY LABELThis is a copy of the labels that accompany each L390PB Gas Insert. We have printed a copy of

50L390PB-2 / HZI390PB-2 Direct Vent Gas InsertPARTS LIST123413228a9101115145a12231916d8202117

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert51PARTS LIST41LOW PROFILE FACEPLATE Part # Description41 398-922 3 sided low profi le faceplate - Sunset b

52L390PB-2 / HZI390PB-2 Direct Vent Gas InsertNOTES

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert53NOTES

54L390PB-2 / HZI390PB-2 Direct Vent Gas InsertNOTES

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert55WARRANTYRegency Fireplace Products are designed with reliability and simplicity in mind. In addition, ou

Printed in CanadaRegency® and Regency Horizon, are trademarks of FPI Fireplace Products International Ltd.© Copyright 2014, FPI Fireplace Products Int

6L390PB-2 / HZI390PB-2 Direct Vent Gas InsertSAFETY LABELThis is a copy of the labels that accompany each HZI390PB Gas Insert. We have printed a copy

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert7REQUIREMENTS5.08: Modifications to NFPA-54, Chapter 10(2) Revise 10.8.3 by adding the following additiona

8L390PB-2 / HZI390PB-2 Direct Vent Gas InsertINSTALLATIONIMPORTANT MESSAGE SAVE THESE INSTRUCTIONSThe L390PB / HZI390PB Gas Inserts must be installe

L390PB-2 / HZI390PB-2 Direct Vent Gas Insert9INSTALLATIONIMPORTANT MESSAGE SAVE THESE INSTRUCTIONSThe Regency Gas Insert must be installed in accord