Regency P40-LP1 User Manual

Tested by:FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4918-661bMODELS: P40-NG1 Natural Gas P40-LP1 Propa

Regency® P40-1 Direct Vent Gas Fireplace10INSTALLATIONINSTALLATION13” Mantel8” Mantel1” Mantel33”to floor2012146481017”21”20126161820414810Combustible

Regency® P40-1 Direct Vent Gas Fireplace 11INSTALLATIONINSTALLATION10-1/4” Above Fireplace6”6”Diagram 11) Frame in the enclosure for the unit with fr

Regency® P40-1 Direct Vent Gas Fireplace12INSTALLATIONINSTALLATIONVENTING INTRODUCTIONThe P40 uses the "balanced fl ue" technology Co A

Regency® P40-1 Direct Vent Gas Fireplace 13INSTALLATIONINSTALLATIONEXTERIOR VENT TERMINATION REQUIREMENTSA= Clearance above grade, veranda, porch, dec

Regency® P40-1 Direct Vent Gas Fireplace14INSTALLATIONINSTALLATIONVENTING ARRANGEMENTS HORIZONTAL TERMINATION (FLEX)Regency® Direct Vent System These

Regency® P40-1 Direct Vent Gas Fireplace 15INSTALLATIONINSTALLATIONRIGID PIPE VENTING SYSTEMSBASIC HORIZONTAL & VERTICAL TERMINATIONSRigid Pipe Ve

Regency® P40-1 Direct Vent Gas Fireplace16INSTALLATIONINSTALLATIONDescriptionSimpsonDirect Vent Pro®Simpson Direct Vent GS®DiscontinuedSelkirk Direct-

Regency® P40-1 Direct Vent Gas Fireplace 17INSTALLATIONINSTALLATIONL676 & L900 Direct Vent FireplaceIMPORTANT NOTE• A Vent Guard is required when

Regency® P40-1 Direct Vent Gas Fireplace18INSTALLATIONINSTALLATIONThe diagram shows all allowable combinations of vertical runs with horizontal termin

Regency® P40-1 Direct Vent Gas Fireplace 19INSTALLATIONINSTALLATIONHH1VHorizontal Venting with Two (2) 90o ElbowsHorizontal Venting with Three (3) 90o

Regency® P40-1 Direct Vent Gas Fireplace2To the New Owner:Congratulations! You are the owner of a state-of-the-art Gas Fireplace by REGENCY®. The P40

Regency® P40-1 Direct Vent Gas Fireplace20INSTALLATIONINSTALLATIONVH1HV1V1VHVertical Venting with Two (2) 90o ElbowsVertical Venting with Three (3) 90

Regency® P40-1 Direct Vent Gas Fireplace 21INSTALLATIONINSTALLATION• Vent must be supported at offsets.• Firestops are required at each fl oor lev

Regency® P40-1 Direct Vent Gas Fireplace22INSTALLATIONINSTALLATIONDiagram 7Diagram 610) Install wall thimble in the center of the 11" (279mm) sq

Regency® P40-1 Direct Vent Gas Fireplace 23INSTALLATIONINSTALLATION6) Continue to assemble pipe lengths.Note: If an offset is necessary in the attic

Regency® P40-1 Direct Vent Gas Fireplace24INSTALLATIONINSTALLATION4) Separate the 2 halves of the wall thimble and securely fasten the one with the t

Regency® P40-1 Direct Vent Gas Fireplace 25INSTALLATIONINSTALLATIONP40-NG1 SYSTEM DATA For 0 to 4500 feet altitudeFront Burner Orifi ce: #44Back Burne

Regency® P40-1 Direct Vent Gas Fireplace26INSTALLATIONINSTALLATIONGAS PIPE PRESSURE TESTINGThe appliance must be isolated from the gas supply piping s

Regency® P40-1 Direct Vent Gas Fireplace 27INSTALLATIONINSTALLATIONCONVERSION KIT #502-969 FROM NG TO LPLP Conversion Kit Contains:Qty. Part # De

Regency® P40-1 Direct Vent Gas Fireplace28INSTALLATIONINSTALLATION14) Re-install pilot shield.15) Set aeration on both front and rear burner for LP ga

Regency® P40-1 Direct Vent Gas Fireplace 29INSTALLATIONINSTALLATIONCONVERSION KIT #502-966 FROM LP TO NGNG Conversion Kit Contains:Qty. Part # De

Regency® P40-1 Direct Vent Gas Fireplace 3TABLE OF CONTENTSConversion Kit #502-969 from NG to LP ...27Conversion Kit #502-966 from L

Regency® P40-1 Direct Vent Gas Fireplace30INSTALLATIONINSTALLATION14) Re-install pilot shield.15) Set aeration on both front and rear burner for LP ga

Regency® P40-1 Direct Vent Gas Fireplace 31INSTALLATIONINSTALLATIONIMPORTANTDangerous operating conditions may occur if the panels are broken.1) Unwr

Regency® P40-1 Direct Vent Gas Fireplace32INSTALLATIONINSTALLATIONRead the instructions below carefully and refer to the pictures. If the logs are br

Regency® P40-1 Direct Vent Gas Fireplace 33INSTALLATIONINSTALLATION11) Place log 03-33 on the back burner in between the burner tubes. Slide the log t

Regency® P40-1 Direct Vent Gas Fireplace34INSTALLATIONINSTALLATION12) Place the bottom of log 03-46 onto the 2nd log stand post and fi t the top of log

Regency® P40-1 Direct Vent Gas Fireplace 35INSTALLATIONINSTALLATIONCompleted Log Set Installation03-3703-3603-4603-3403-3203-4703-4003-38(1)03-38(2)16

Regency® P40-1 Direct Vent Gas Fireplace36INSTALLATIONINSTALLATIONDiagram 1Diagram 3STANDARD FLUSH DOORNOTE: Install Finishing Trim prior to installi

Regency® P40-1 Direct Vent Gas Fireplace 37INSTALLATIONINSTALLATIONWIRING DIAGRAM CAUTION: Label all wires prior to disconnection when servicing contr

Regency® P40-1 Direct Vent Gas Fireplace38INSTALLATIONINSTALLATIONLeave these twoscrews securedRemove thecenter screwLoosen thesefour screwsLeave thes

Regency® P40-1 Direct Vent Gas Fireplace 39INSTALLATIONINSTALLATIONUpper Air RegisterSimply push in the Full Screen Door Frame until it aligns against

Regency® P40-1 Direct Vent Gas Fireplace4INSTALLATIONINSTALLATIONThis is a copy of the label that accompanies each P40-NG1 and P40-LP1 Direct Vent Ga

Regency® P40-1 Direct Vent Gas Fireplace40OPERATIONOPERATING INSTRUCTIONSOPERATING INSTRUCTIONS1) Read and understand these instructions before opera

Regency® P40-1 Direct Vent Gas Fireplace 41OPERATIONOPERATING INSTRUCTIONSDuring the fi rst few fi res, a white fi lm may develop on the glass front as

Regency® P40-1 Direct Vent Gas Fireplace42OPERATIONOPERATING INSTRUCTIONSSUMMARY OF CONTROLS For the Manual Control Box, located on right hand side of

Regency® P40-1 Direct Vent Gas Fireplace 43OPERATIONOPERATING INSTRUCTIONSCOPY OF LIGHTING PLATE INSTRUCTIONSTO TURN OFF GAS APPLIANCEFOR YOUR SAFETY

Regency® P40-1 Direct Vent Gas Fireplace44MAINTENANCEMAINTENANCEMAINTENANCE INSTRUCTIONS1) Always turn off the gas valve before cleaning. For relight

Regency® P40-1 Direct Vent Gas Fireplace 45MAINTENANCEMAINTENANCECAUTION: Wear gloves when removing damaged or broken glass.WARNING: Do not operate th

Regency® P40-1 Direct Vent Gas Fireplace46MAINTENANCEMAINTENANCEVALVE REPLACEMENT1) Shut off the main gas supply and unplug the power to the ECS syst

Regency® P40-1 Direct Vent Gas Fireplace 47MAINTENANCEMAINTENANCE1) Unplug the power source.2) Remove the manual control panel by removing the 2 scr

Regency® P40-1 Direct Vent Gas Fireplace48MAINTENANCEMAINTENANCEPower Module3) Remove the Control Module by lifting it up off of the velcro and pull

Regency® P40-1 Direct Vent Gas Fireplace 49PARTS LISTPARTS LISTMAIN ASSEMBLY Part # Description

Regency® P40-1 Direct Vent Gas Fireplace 5INSTALLATIONINSTALLATION5.08: Modifications to NFPA-54, Chapter 10(2) Revise 10.8.3 by adding the following

Regency® P40-1 Direct Vent Gas Fireplace50PARTS LISTPARTS LIST120122121125127128129126VALVE TRAY ASSEMBLY Part # Description

Regency® P40-1 Direct Vent Gas Fireplace 51PARTS LISTPARTS LISTFLUSH DOOR & LOUVERS Part # Description

Regency® P40-1 Direct Vent Gas Fireplace52NOTES_______________________________________________________________________________________________________

Regency® P40-1 Direct Vent Gas Fireplace 53NOTES______________________________________________________________________________________________________

Regency® P40-1 Direct Vent Gas Fireplace54NOTES_______________________________________________________________________________________________________

Regency® P40-1 Direct Vent Gas Fireplace 55WARRANTYRegency® Fireplace Products are designed with reliability and simplicity in mind. In addition, our

Installer: Please complete the following informationDealer Name & Address: _______________________________________________________________________

Regency® P40-1 Direct Vent Gas Fireplace6INSTALLATIONINSTALLATION34" (864mm)40” (1016mm)8” (203mm) Outer Dia.5” (127mm) Inner Dia.40” (1016mm)35-

Regency® P40-1 Direct Vent Gas Fireplace 7INSTALLATIONINSTALLATIONIMPORTANT MESSAGE SAVE THESE INSTRUCTIONSThe P40 Direct Vent Fireplace must be inst

Regency® P40-1 Direct Vent Gas Fireplace8INSTALLATIONINSTALLATIONHEARTH REQUIREMENTSA 40" (1016mm) wide x 16" (406mm) deep x 1-1/2" (38

Regency® P40-1 Direct Vent Gas Fireplace 9INSTALLATIONINSTALLATIONCLEARANCESThe clearances listed below are minimum distances unless otherwise stated: